Inhoudsopgave
Advertenties
4. Install battery in the tractor, making sure the terminal
posts are positioned properly.
Install the battery
hold down assembly. Tighten the nuts only enough
to keep the battery from moving. DO NOT OVER-
TIGHTEN.
5. Reinstall the battery cables as shown in Fig. 2-6 and
Fig.
2-7.
Grease all exposed metal surfaces of the
battery terminals.
REAR
,
Fig. 2-7 O-Series Battery Installation
Check Engine Oil Level
Check that the engine oil is at the proper level and
for oil leaks. Engines are filled with SAE 30 oil at the
factory. If the tractor is to be operated in cold tempera-
tures, it may be necessary to change the oil. Refer to the
Engine Oil Temperature-Viscosity Chart in Section 1.
Check Transmission Oil Level
Check that the transmission oil is at the proper level
!
an'd for oil leaks. Oil specifications are:
4-Speed Transmission - SAE 90
8-Speed Transmission - SAE 140
Automatic Transmission - SAE
1
OW-30 to 10W-40
Install Seat (C and D-Series Only)
Mount seat to seat springs with lockwashers and bolts on
C-Series models. The seat springs are secured to the bottom
2-3
SECTION
2~
of seat pivot plate on D-Series tractors. Remove the hard-
ware and re-attach seat springs to top side of seat pivott
plate.
See Fig. 2-8.
Fig. 2-8 D-Series Seat Installation
Check Wiring and Attaching Hardware
I
~
)
Visually inspect for any loose connections and tight-
en as required.
Check routing of wires to make sure
they will not be disturbed by any moving part that
could cause a short.
Check that nuts, bolts, and other fasteners are in
place and tight.
Fill the Fuel Tank
Use a good grade of regular or unleaded gasoline (90
octane or higher).
Open the fuel shut-off valve and
check fuel hose and fittings for leaks.
Lubricate Tractor
Grease all lube points as shown in the maintenance
section of the tractor Owner's Manual (front axle, both
front wheel spindles, both front wheels, and steering
gear; on D-Series tractors, also grease the steering gear
bell crank).
Use No. 2 mUlti-purpose lithium grease.
Test Tractor Operation
A. As applicable, check or test operation of the following:
1. Engine, choke, and throttle controls
2. Gauges
Advertenties
Inhoudsopgave
